19006 - Wapekeka First Nation Infrastructure Upgrades

Water Distribution

1. Watermain: 1,387 m of new 300 mm Ø HDPE DR11 pipe c/w insulation, heat trace cable, and tracer wire (insulated pipe supplied on-site by owner);
2. Gate Valves:  4 – 300 mm Ø Gate Valves, Installation only (valve, valve box, insulation kit, flange adapters / back up rings / Stainless steel bolt packs and concrete block supplied on-site by owner);
3. Gate Valves:  4 – 300 mm Ø Gate Valve:  Supply and Install c/w valve box, insulation kit,  flange adapters / back up rings / Stainless steel bolt packs and concrete block Supply and Install c/w valve box, insulation kit,  flange adapters / back up rings / Stainless steel bolt packs and concrete block;
4. On-Line Fire Hydrant Set:  8 – Hydrant sets, Installation only (material supplied on-site by owner for each Hydrant Set);
5. Heat Trace Panels on Watermain:  Supply & install four heat trace panels c/w panel enclosure & structure, associated end caps/boxes & structure, direct bury power supply cable, meter, service breaker, circuit panel, heat trace controller, junction box.

1. Sanitary Forcemain:  950 m of 100 mm Ø HDPE DR11 pipe c/w insulation, heat trace cable, and tracer wire (insulated pipe supplied on-site by owner);
2. Heat Trace Controllers on Sanitary Forcemain: Supply & install three heat trace panels c/w panel enclosure & structure, associated end caps/boxes & structure, direct bury power supply cable, meter, service breaker, circuit panel, heat trace controller, junction box;
3. 1200 mm Ø Precast Concrete Air Relief Chamber:  Excavation, frost straps, insulation and frost cover, backfill, frame & cover, supply and install air relief valve (precast concrete chamber, base, cone, boots, frost straps & anchors, sealant, frame & cover all supplied on-site by owner);
4. Sanitary Lift Station #1 Retrofit (SLS-1):  Removals: Existing pumps, discharge connection elbows, pump rails, all station piping, valves, floats, and other station equipment, excluding access ladder and vent pipes; Supply & Install: Pumps, pump bases, pump guides, lift chain, discharge connection elbows, check valves, gate valves, air relief valve, emergency overflow, 100  mm station piping, floats, misc. station equipment;
5. New 2.4 m Ø Sanitary Lift Station Chamber (SLS-3):  Supply and Install granular base, cast-in-place ballast ring, frost strap, damproofing, insulation/grade-board/flashing, backfill, interior waterproofing,  hatches, ladder, grab bar, 150 Ø vent, lifting davit, station piping, valves, pumps & guide bars, floats, misc. station equipment; (Pre-cast concrete riser sections, cap & base, frost straps & anchors, link-seals, two (2) 900 mm x 900 mm access/service hatches, bolt-on access ladder, and grab bar all supplied on-site by owner);
6. SLS-1 Control Panel: Supply and installation c/w support, enclosure, meter, service breaker, circuit panel, pump controller, direct bury power supply cable
7. SLS-3 Control Panel: Supply and installation c/w support, enclosure, meter, service breaker, circuit panel, pump controller, direct bury power supply cable.

1. Road Construction:  420 m of new road c/w 300 mm Gran. ‘B’ Type III Subbase and 150 mm Screened Gran. ‘B’ Type III Select Surface Course;